EPDM Coatings
rvupgradestore.com Composet Products Custom Yacht Interiors

Author Topic: Travelling through mountains... lost trailer brakes!!  (Read 1753 times)

1down

  • ---
  • Posts: 23
Travelling through mountains... lost trailer brakes!!
« on: May 07, 2017, 10:21:55 PM »
 Set out this morning with our new used 5th wheel.  Trailer brakes working fine.  Then started getting message from 2015 3500hd that the "trailer brakes need serviced" and i would have no trailer brakes.  This became more frequent and of longer duration as the 400 mile trip progressed.  The problem would come and go but became progressively worse until I had no trailer brakes at all the last 100 miles from Payson to Mesa.   Fortunately the engine brake provided excellent braking.   
Any ideas on the cause of the progressive brake disappearance?
« Last Edit: May 10, 2017, 05:43:05 PM by scottydl »
2004 Keystone Challenger 33' Fifth Wheel
2015 Chevrolet 3500HD SRW
Belen, NM

Arch Hoagland

  • ---
  • Posts: 1553
  • Clovis CA
Re: Travelling through mountains... lost trailer brakes!!
« Reply #1 on: May 08, 2017, 12:58:53 AM »
I'd suggest buying an IR gun and shoot the tires and brakes periodically to see if they are dragging and overheating.

What year, make and model truck and trailer do you have?



How to make a signature for your RV so we can serve you better.

1. Click "Profile" button towards the top of the screen.

2. Scroll down a ways and select "Modify Profile"

3. Select Forum Profile

4. Fill it out and click on "Change profile".
2004 Monaco La Palma 36 DBD
W22, 8.1 gas,  Allison 1000 Transmission
7.1 MPG over 80,000 miles

2000 Lexus RX300, 4020lb
U.S. Gear Braking System

BoonDocker Bob

  • Guest
Re: Travelling through mountains... lost trailer brakes!!
« Reply #2 on: May 08, 2017, 06:31:20 AM »
Quote
Travelling through mountains... lost trailer brakes!!

Quote
Set out this morning with our new used 5th wheel.  Trailer brakes working fine


Hummmm ...   being a semi truck driver for over 36 yrs .....    all I can say is that I have seen this a LOT . Could it be possibly be driver fault ?  LOTS of people have absolutely NO idea how to go down ( or up ) hills/mountains properly . ( and yes , that includes a LOT of these "new" truck drivers out here today )
Lets here about  HOW your going down the hills  and we can go from there . Don't always be so fast  to make it equipment  failure/fault .

lynnmor

  • ---
  • Posts: 562
Re: Travelling through mountains... lost trailer brakes!!
« Reply #3 on: May 08, 2017, 06:47:00 AM »
Likely an intermittent electrical fault, check connector, wires, wires inside axle tube and brake magnets.

Gary RV_Wizard

  • Forum Staff
  • ---
  • *
  • Posts: 61026
  • RVer Emeritus
Re: Travelling through mountains... lost trailer brakes!!
« Reply #4 on: May 08, 2017, 06:48:05 AM »
I would start with the electrical connections, especially the plug/receptacle where the trailer hooks to the tow vehicle.

That message isn't very helpful. Is it from a RAM built-in (MOPAR factory installed) brake controller or an add-on? If  something that was added, what brand & model?  Most Tekonsha controllers give more specific messages concerning the type of fault. If Ram (MOPAR), what does your Ram owner manual say about it? And what settings are you using on it?
Gary
--------------
Gary Brinck
Summers: Black Mountain, NC
Home: Ocala National Forest, FL

1down

  • ---
  • Posts: 23
Re: Travelling through mountains... lost trailer brakes!!
« Reply #5 on: May 08, 2017, 07:43:19 AM »
I'd suggest buying an IR gun and shoot the tires and brakes periodically to see if they are dragging and overheating.

What year, make and model truck and trailer do you have?



How to make a signature for your RV so we can serve you better.

1. Click "Profile" button towards the top of the screen.

2. Scroll down a ways and select "Modify Profile"

3. Select Forum Profile

4. Fill it out and click on "Change profile".

I shot the tires with my IR gun... all were within a couple degrees of each other..  73 to 74 degrees.

Thanks for the profIle advice ...
2004 Keystone Challenger 33' Fifth Wheel
2015 Chevrolet 3500HD SRW
Belen, NM

1down

  • ---
  • Posts: 23
Re: Travelling through mountains... lost trailer brakes!!
« Reply #6 on: May 08, 2017, 07:51:19 AM »
Likely an intermittent electrical fault, check connector, wires, wires inside axle tube and brake magnets.

I was thinking intermittent but the problem grew steadily.

This is a used trailer that hadn't seen much road use.  It had the original tires from 2004 when I bought it two months ago.  A friend bought it used , with not much use, and  he used it parked as a second home for work. 
I'm wondering if some corrosion  hasn't set in.
2004 Keystone Challenger 33' Fifth Wheel
2015 Chevrolet 3500HD SRW
Belen, NM

1down

  • ---
  • Posts: 23
Re: Travelling through mountains... lost trailer brakes!!
« Reply #7 on: May 08, 2017, 07:58:42 AM »
I would start with the electrical connections, especially the plug/receptacle where the trailer hooks to the tow vehicle.

That message isn't very helpful. Is it from a RAM built-in (MOPAR factory installed) brake controller or an add-on? If  something that was added, what brand & model?  Most Tekonsha controllers give more specific messages concerning the type of fault. If Ram (MOPAR), what does your Ram owner manual say about it? And what settings are you using on it?

Yep.  I unplugged several times in order to reset the truck info readout.  It worked at first, the truck recognized that a trailer was plugged in but when I hit the brakes it would give me the "trailer brakes need service" message.  The problem became more frequent and longer duration as the trip wore on until the truck built in brake controller would no longer interface with the trailer brakes.
2004 Keystone Challenger 33' Fifth Wheel
2015 Chevrolet 3500HD SRW
Belen, NM

Rene T

  • ---
  • Posts: 10161
  • Great being on the right side of the grass
Re: Travelling through mountains... lost trailer brakes!!
« Reply #8 on: May 08, 2017, 07:59:14 AM »
I was thinking intermittent but the problem grew steadily.

This is a used trailer that hadn't seen much road use.  It had the original tires from 2004 when I bought it two months ago.  A friend bought it used , with not much use, and  he used it parked as a second home for work. 
I'm wondering if some corrosion  hasn't set in.

I hope the tires your have on it now aren't the originals. If they are, you need to replace them ASAP. RV tires are typically only good for 8 or 9 years at the most even if the tread looks new.
Rene & Lucille & co-pilot Buddy
AKA  Pep N Mem
2011 Chevy Duramax 2500 HD 4X4
2011 Montana High Country 343RL
From the Granite State of NH
& Florida Snowbird in Lakeland FL

1down

  • ---
  • Posts: 23
Re: Travelling through mountains... lost trailer brakes!!
« Reply #9 on: May 08, 2017, 08:05:39 AM »
I hope the tires your have on it now aren't the originals. If they are, you need to replace them ASAP. RV tires are typically only good for 8 or 9 years at the most even if the tread looks new.

New tires were installed last week.
2004 Keystone Challenger 33' Fifth Wheel
2015 Chevrolet 3500HD SRW
Belen, NM

Rene T

  • ---
  • Posts: 10161
  • Great being on the right side of the grass
Re: Travelling through mountains... lost trailer brakes!!
« Reply #10 on: May 08, 2017, 08:07:03 AM »
New tires were installed last week.

WHEW!!!!
Rene & Lucille & co-pilot Buddy
AKA  Pep N Mem
2011 Chevy Duramax 2500 HD 4X4
2011 Montana High Country 343RL
From the Granite State of NH
& Florida Snowbird in Lakeland FL

Hammster

  • ---
  • Posts: 308
Re: Travelling through mountains... lost trailer brakes!!
« Reply #11 on: May 08, 2017, 08:14:54 AM »
Yep.  I unplugged several times in order to reset the truck info readout.  It worked at first, the truck recognized that a trailer was plugged in but when I hit the brakes it would give me the "trailer brakes need service" message.  The problem became more frequent and longer duration as the trip wore on until the truck built in brake controller would no longer interface with the trailer brakes.

Once the controller would no longer interface with trailer brakes, you stopped, unplugged trailer cable, replugged in and brakes still wouldn't work? Just wondering what else was tried after it got to the would no longer interface stage.

I know that road from Payson to Mesa (my dad lives in Payson). That's quite a road to go down, especially when just leaving Payson, without brakes. Fortunately there has been some good improvements made to that road to make it somewhat safer, and really glad you made it down safely.
2016 GMC Sierra 2500HD Denali. 6.6L Diesel. 4x4
Arctic Fox 22G.

SargeW

  • Forum Staff
  • ---
  • *
  • Posts: 6402
  • Life is better on the road!
Re: Travelling through mountains... lost trailer brakes!!
« Reply #12 on: May 08, 2017, 09:51:17 AM »
Although your fault sounds electrical, it doesn't hurt to check the brake pads either. Axles by Lippert tend to use extremely cheap grease seals which allow the bearing grease to heat up then blow out all over the inside of the drum, brake pads, and magnets.  I speak from experience.  You can check them with a good flashlight by crawling under the rig and peeking between the backing plate and the drum. If it is greased, you will see it everywhere. 
Marty--
2017 Tiffin Allegro Bus 40SP
Cummins ISL 450 HP/Powerglide chassis
Visit our new travel blog! http://www.mytripjournal.com/rvnchickTNG
Support your local Police Officer, Fire Fighter and Military!

xrated

  • ---
  • Posts: 465
Re: Travelling through mountains... lost trailer brakes!!
« Reply #13 on: May 08, 2017, 10:35:12 AM »
1down.....no disrespect intended, but if you had early warnings about the trailer brakes not working correctly, why would you continue on a 400 mile trip, especially through the mountains?  Glad you made it safely, but that could have been a story with a not so happy ending.
2016 F350 Crew Cab Dually King Ranch Diesel
2017 Keystone Fuzion Impact 303
Track Bike  2008 GSX-R750
"If it ain't Fast......It ain't Fun

Lynx0849

  • ---
  • Posts: 52
Re: Travelling through mountains... lost trailer brakes!!
« Reply #14 on: May 08, 2017, 10:40:51 AM »
Just for curiosity, what would inform the brake controller that the trailer brakes need servicing?

Is it just that it doesn't see a reasonable load on the brake circuit?

My Prodigy only lets me know it sees the trailer brakes are connected.

Gods Country

  • ---
  • Posts: 488
Re: Travelling through mountains... lost trailer brakes!!
« Reply #15 on: May 08, 2017, 10:54:21 AM »
Do you have a factory option installed controller?

If so I would suspect the controller.  Do check your wiring and and pads as suggested, but IMO if they seem to work and lock up appropriately I would look at the controller.  IMO truck manufacturers have managed to screw up everything that was once simple and reliable, like a dash mounted brake controller.

Joezeppy

  • ---
  • Posts: 1687
Re: Travelling through mountains... lost trailer brakes!!
« Reply #16 on: May 08, 2017, 11:46:58 AM »
IMO truck manufacturers have managed to screw up everything that was once simple and reliable, like a dash mounted brake controller.


LOL - I agree. No troubles with my factory controller so far (knock wood) but I have heard horror stories of troubled systems where the truck dealer says the controller is ok and the RV dealer says the trailer brakes are ok. Well then why don't my brakes work???
Joe & Kim
Upstate NY - Kuyahoora Valley
2010 GMC Sierra 2500HD - 6.0L
2017 Keystone Hideout 295BHS
Andersen Ultimate Aluminum 5th wheel hitch

Gods Country

  • ---
  • Posts: 488
Re: Travelling through mountains... lost trailer brakes!!
« Reply #17 on: May 08, 2017, 12:03:02 PM »

LOL - I agree. No troubles with my factory controller so far (knock wood) but I have heard horror stories of troubled systems where the truck dealer says the controller is ok and the RV dealer says the trailer brakes are ok. Well then why don't my brakes work???

When I was shopping around for a new controller I considered an OEM for my truck.  After laughing at the cost and reading the countless stories of the OEM controllers I purchased a Prodigy and happy I did. 


Old Blevins

  • ---
  • Posts: 506
Re: Travelling through mountains... lost trailer brakes!!
« Reply #18 on: May 08, 2017, 06:41:36 PM »
1down, you may already have run across this, but just in case, I thought I'd share this thread from the Duramax forum.  It may cast some light on the possible cause.
http://www.duramaxforum.com/forum/gauges-electronics-wiring/120320-itbc-service-trailer-brake-system-resolution.html
Jim
------------------------------------
2006 Silverado SRW 1-Ton 4WD Diesel
2006 Arctic Fox 29V
1985 Brawley 2-Horse Straight-Load Trailer

1down

  • ---
  • Posts: 23
Re: Travelling through mountains... lost trailer brakes!!
« Reply #19 on: May 08, 2017, 10:08:58 PM »
1down, you may already have run across this, but just in case, I thought I'd share this thread from the Duramax forum.  It may cast some light on the possible cause.
http://www.duramaxforum.com/forum/gauges-electronics-wiring/120320-itbc-service-trailer-brake-system-resolution.html

Now that is interesting.   

Im taking the trailer in tomorrow, bright and early, for inspection and repair.

I ordered a Tekonsha P3 with wiring kit to replace the oem brake controlder so I can bypass the on board stuff.
So hopefully everything will sort out here shortly.
« Last Edit: May 09, 2017, 05:19:15 PM by scottydl »
2004 Keystone Challenger 33' Fifth Wheel
2015 Chevrolet 3500HD SRW
Belen, NM

1down

  • ---
  • Posts: 23
Re: Travelling through mountains... lost trailer brakes!!
« Reply #20 on: May 08, 2017, 10:16:37 PM »
Once the controller would no longer interface with trailer brakes, you stopped, unplugged trailer cable, replugged in and brakes still wouldn't work? Just wondering what else was tried after it got to the would no longer interface stage.

I know that road from Payson to Mesa (my dad lives in Payson). That's quite a road to go down, especially when just leaving Payson, without brakes. Fortunately there has been some good improvements made to that road to make it somewhat safer, and really glad you made it down safely.

Coming off the Mogollon Rim at 45 mph, the truck exhaust brake kept control of the speed the entire drop.  Same with the Payson to Rye drop.
Had the load dominated the exhaust brake I would be waiting for brake repair in Show Low instead of here in Mesa.
Hopefully will get it squared away tomorrow.
2004 Keystone Challenger 33' Fifth Wheel
2015 Chevrolet 3500HD SRW
Belen, NM

robertusa123

  • ---
  • Posts: 1507
Re: Travelling through mountains... lost trailer brakes!!
« Reply #21 on: May 09, 2017, 09:32:18 PM »
I had my trailer brake controler smoke on me going over a mountaintop  myself....   had to drop it to 2nd gear and grind down the mt at 25mph all the way down
1996  26ft. 3 kids 2 dog and the wife too

alan6051964

  • ---
  • Posts: 169
Re: Travelling through mountains... lost trailer brakes!!
« Reply #22 on: May 09, 2017, 09:37:37 PM »
I had my trailer brake controler smoke on me going over a mountaintop  myself....   had to drop it to 2nd gear and grind down the mt at 25mph all the way down
lol, 25 mph down a mountain side sure beats the crap out of going down that mountain side at the speed of sound !..lol. I've been down that road out of Halbrook,az, 6 degree's I think it got down to ?, all the way to payson, my lord, that's a ride I don't want to see ever again pulling anything !..lol.
1992 22ft Fleetwood wilderness TT

1down

  • ---
  • Posts: 23
Re: Travelling through mountains... lost trailer brakes!!
« Reply #23 on: May 10, 2017, 12:57:16 PM »
Although your fault sounds electrical, it doesn't hurt to check the brake pads either. Axles by Lippert tend to use extremely cheap grease seals which allow the bearing grease to heat up then blow out all over the inside of the drum, brake pads, and magnets.  I speak from experience.  You can check them with a good flashlight by crawling under the rig and peeking between the backing plate and the drum. If it is greased, you will see it everywhere.


Ding ding ding ... and we have a winner!!!

I was able to get the camper into Straight  Line Sus pension in Mesa az early Tuesday morning.   Mike squeezed me in even though he is extremely busy.  He found lots of evidence of unuse and he found leaking grease seals which caused the brake loss.  He got it cleaned up, repaired and adjusted the brakes.  Though it was only a few miles back to camp I stepped on the trailer brakes aggressively to see if I could get an error message.   I'm happy to report it worked fine. But I'm still gonna install the tekonsha but leave it unplugged in case I need it. 
Thanks for all the comments and suggestions.
« Last Edit: May 10, 2017, 05:43:27 PM by scottydl »
2004 Keystone Challenger 33' Fifth Wheel
2015 Chevrolet 3500HD SRW
Belen, NM

Gods Country

  • ---
  • Posts: 488
Re: Travelling through mountains... lost trailer brakes!!
« Reply #24 on: May 10, 2017, 01:44:17 PM »
Good to hear.  Hopefully that was it.




kdbgoat

  • ---
  • Posts: 4220
Re: Travelling through mountains... lost trailer brakes!!
« Reply #25 on: May 10, 2017, 02:16:39 PM »

Ding ding ding ... and we have a winner!!!

I was able to get the camper into Straight  Line Sus pension in Mesa az early Tuesday morning.   Mike squeezed me in even though he is extremely busy.  He found lots of evidence of unuse and he found leaking grease seals which caused the brake loss.  He got it cleaned up, repaired and adjusted the brakes.  Though it was only a few miles back to camp I stepped on the trailer brakes aggressively to see if I could get an error message.   I'm happy to report it worked fine. But I'm still gonna install the tekonsha but leave it unplugged in case I need it. 
Thanks for all the comments and suggestions.

Another case for hand packing bearings, and not using the easy lube system. I'm glad you found the problem, and got it fixed.
I know you believe you understand what you think I said,
But I am not sure you realize what you heard is not what I meant


2016 Leprechaun 319DS

SargeW

  • Forum Staff
  • ---
  • *
  • Posts: 6402
  • Life is better on the road!
Re: Travelling through mountains... lost trailer brakes!!
« Reply #26 on: May 10, 2017, 05:22:03 PM »
Good to hear your guy got it handled. Hopefully your guy changed the grease seals out. Don't want a replay of that experience.
Marty--
2017 Tiffin Allegro Bus 40SP
Cummins ISL 450 HP/Powerglide chassis
Visit our new travel blog! http://www.mytripjournal.com/rvnchickTNG
Support your local Police Officer, Fire Fighter and Military!

Hammster

  • ---
  • Posts: 308
Re: Travelling through mountains... lost trailer brakes!!
« Reply #27 on: May 10, 2017, 05:36:28 PM »

Ding ding ding ... and we have a winner!!!

 ...and he found leaking grease seals which caused the brake loss.  He got it cleaned up, repaired and adjusted the brakes.  Though it was only a few miles back to camp I stepped on the trailer brakes aggressively to see if I could get an error message.   I'm happy to report it worked fine...

What great news. Glad the problem was found and fixed and brakes seem to be working as well as they should. Really great news.
« Last Edit: May 10, 2017, 05:42:44 PM by scottydl »
2016 GMC Sierra 2500HD Denali. 6.6L Diesel. 4x4
Arctic Fox 22G.

1down

  • ---
  • Posts: 23
Re: Travelling through mountains... lost trailer brakes!!
« Reply #28 on: June 06, 2017, 09:54:22 PM »
Well, I haven't posted regarding the brake issue for awhile.  The trip was 4,234.4 miles long starting at Belen, NM to Phoenix, Sacramento, Tillamook, Pendelton, Boise, Ogden, Farmington and then home and I still had "Service Trailer Brake" messages.   Sometimes a good shove of the trailer plug would remedy the situation and sometimes the truck would just resume trailer brake service.  An added wrinkle was that "Stabiltrak" would go out first and then the "Service Trailer Brakes" warning would appear - not all the time but most times. 

While in Phoenix I ordered a Tekonsha P3 and adapter wire kit for my truck and plugged it in.  The Tekonsha has never been able to detect the trailer.  So I suspect a faulty connection somewhere. 

We're due to head to Michigan in a couple weeks so I need to start taking a good look at the truck and trailer connections. 

Also, last time the trailer brakes disappeared I stopped and checked that the brake lights and running lights worked despite the trailer brake fault. 

I'll keep plugging away on it 



2004 Keystone Challenger 33' Fifth Wheel
2015 Chevrolet 3500HD SRW
Belen, NM

Lou Schneider

  • Forum Staff
  • ---
  • *
  • Posts: 7409
Re: Travelling through mountains... lost trailer brakes!!
« Reply #29 on: June 07, 2017, 12:23:43 AM »
An easy way to troubleshoot trailer brakes is to have someone hold the brakes on while you pass a compass in front of each wheel.

Electric brakes use an electromagnet dragging against the face of the rotating brake drum to pull on the linkage and apply the brakes.  More current through the electromagnet = more pull on the brake linkage.  A functioning electromagnet will strongly deflect a compass needle as you pass the compass in front of it.

If a magnet is not activating, you either have a bad connection going to that wheel or the electromagnet is open.  Sometimes they wear down enough as they drag against the brake drum to let the electric coils rub against the drum and wear through the wire.

The brake shoes could also be far enough out of adjustment that a wheel runs out of linkage travel before the brakes engage, but I'd test the electromagnets first.
« Last Edit: June 07, 2017, 12:34:41 AM by Lou Schneider »

 

Hosted by Over The Network