EPDM Coatings
rvupgradestore.com Composet Products PO Box Zone
Over The Network Custom Yacht Interiors

Author Topic: 2002 Journey Question - Air System for Brakes and Bags  (Read 179 times)

Top38

  • ---
  • Posts: 36
2002 Journey Question - Air System for Brakes and Bags
« on: October 03, 2017, 10:00:56 AM »
This may be a Freightliner question but was wondering where the air pressure sensors are for the air brakes and air bags on this coach would be.
I had a low air pressure alarm go off for about 5 seconds where the rear air pressure gauge went to 0 then popped right back to 130 PSI so I know it was
not low and figured that there must be a loose connection or the air pressure sensor is starting to go bad.

thanks

Gary RV_Wizard

  • Forum Staff
  • ---
  • *
  • Posts: 60355
  • RVer Emeritus
Re: 2002 Journey Question - Air System for Brakes and Bags
« Reply #1 on: October 03, 2017, 11:34:36 AM »
I think the warning buzzer is built into the dash gauge assembly, so you may have a loose air connection there. There have been other reports of bad connections there. As I understand it,though, the alarms triggered by the gauge action, so anything that makes the needle on the gauge go down will trigger the alarm.

Contact Freightliner Customer Service for chassis air system info and have the last 6 digits of the VIN handy. 1-800-FTL-HELP
Gary
--------------
Gary Brinck
Summers: Black Mountain, NC
Home: Ocala National Forest, FL

Top38

  • ---
  • Posts: 36
Re: 2002 Journey Question - Air System for Brakes and Bags
« Reply #2 on: October 03, 2017, 04:40:17 PM »
Thanks, I don't think that the gauge has an actual air line going to it, meaning a mechanical gauge, it moved up and down way to quick so it must be an electrical gauge that has a sending unit somewhere. But something could be getting loose at the gauge end too.

RedT

  • ---
  • Posts: 374
Re: 2002 Journey Question - Air System for Brakes and Bags
« Reply #3 on: October 03, 2017, 06:18:16 PM »
I thin your chassis uses a Vehicle Data Unit (VDU).  You should be able to find several articles if you do a search on this forum.
RedT, US Air Force Retired
2004 Itasca Meridian
2003 Jeep Liberty
M&G Brake System, VMSpc
Pressure Pro TPMS

Top38

  • ---
  • Posts: 36
Re: 2002 Journey Question - Air System for Brakes and Bags
« Reply #4 on: October 04, 2017, 08:32:46 AM »
Yes, it appears that I have the same VDU issue described from that search. Thanks.

2dalake

  • ---
  • Posts: 297
Re: 2002 Journey Question - Air System for Brakes and Bags
« Reply #5 on: October 05, 2017, 07:04:14 PM »
I owned a 2002 Journey for 8 years.  Had same issue....low air alarms, gauge goes to 0.  However, no other evidence of low air....brakes still work, etc.

It may surely be the VDU.  The air gauges get all their info from the VDU/VDC and they were known to have cold solder joints that would cause this particular problem.  I removed my VDU, opened it and re-soldered the cold joints.  It fixed it for about 2 1/2 years before it started doing it again.  I got a new VDU the second time.   

Here is an article that may be helpful:



« Last Edit: October 05, 2017, 07:11:04 PM by 2dalake »
2007 Country Coach Allure 470 Siskiyou Summit, 2012 CRV Toad; 2014 F150 Toad; Air Force One toad brake.

judway

  • ---
  • Posts: 1014
  • We are at the house in West Melbourne, Florida
Re: 2002 Journey Question - Air System for Brakes and Bags
« Reply #6 on: October 05, 2017, 07:14:36 PM »
I removed my VDU, opened it and re-soldered the cold joints. It has been working great ever since.
Wayne
2003 Itasca Horizon 36LD
2017 Chevrolet Equinox LT
Remco Towbar, Demco Baseplate & Air Force One Brake
1995 GMC Sierra Z71
No Dogs      No Cats!
Retired Electrical Engineer (University of Cincinnati)
W4SRR

 

Hosted by Over The Network