EPDM Coatings
rvupgradestore.com Composet Products Custom Yacht Interiors

Author Topic: Generac Generator won't Start  (Read 8193 times)

qc91

  • Posts: 4
Generac Generator won't Start
« on: December 05, 2012, 01:11:04 AM »
we have a Generac 09712-2 NP-50G in are RV and recently it doesn’t start we check the fuel pump and gas is moving thru it we did spry some carburetor cleaner in the carburetor and it did run for about 3 to 4 Seconds then quits any help would be appreciated

Thanks

harris155

  • ---
  • Posts: 106
  • Port Dover, Ontario
Re: Generac Generator won't Start
« Reply #1 on: December 05, 2012, 06:05:31 AM »
A lot of generators have a low oil pressure cutout, is the level OK
Canadian Snowbirds, Monaco Monarch 33SFS with Jeep TJ in Tow
Apache Junction, AZ and Port Dover, ON

Gary RV_Wizard

  • Forum Staff
  • ---
  • *
  • Posts: 61015
  • RVer Emeritus
Re: Generac Generator won't Start
« Reply #2 on: December 05, 2012, 06:11:18 AM »
If spraying the carb works, then you have a fuel delivery problem. Could be the carb itself is gummed up, or could be that fuel delivery pressure is low or full of air bubbles from a leak in the feed line from the tank. A pinhole or tiny crack is enough to suck air or reduce pressure.

One test is to put a short length of new tubing on the fuel pump intake and put other end in a can of gas. If that works, you know the problem is in the fuel line. If it doesn't work, the problem is in the pump or carb.

If you haven't been running the generator regularly, chances are good the carb is bllocked with varnish from evaporated fuel. It will need a thorough cleaning of the jets or a re-build.
Gary
--------------
Gary Brinck
Summers: Black Mountain, NC
Home: Ocala National Forest, FL

dan2

  • ---
  • Posts: 193
  • 1988 Pace Arrow, P-30 GMC Upgrade, Banks, 03 F-150
Re: Generac Generator won't Start
« Reply #3 on: December 05, 2012, 11:55:59 AM »
And some Seafoam in the can would be nice.... :)

Good luck,
Dan

qc91

  • Posts: 4
Re: Generac Generator won't Start
« Reply #4 on: December 05, 2012, 12:30:30 PM »
HI, Thanks everyone for the help we are going work on it this weekend I will try all of your advice and let all of you know thanks again for all the help

Thanks

UncleShiloh

  • ---
  • Posts: 94
Re: Generac Generator won't Start
« Reply #5 on: December 05, 2012, 03:43:38 PM »
Biggest issue is that generator aint spelled Onan..lol. I was having fits for a while with my REAL generator and got a mechanical minded fellow to come look at it. It was the electrical contact points was the issue. Aint had a problem since that time and that has been many moons ago. Not sure its the same malfunction of course but would be something to put on the to-do list before having some scammy RV fixit place relieve you of a tub of money.

Victory

  • Posts: 4
Re: Generac Generator won't Start
« Reply #6 on: December 07, 2012, 02:01:18 PM »
Is it possible that you are low on fuel? If the generator runs off of fuel tank, the fuel line to generator is usually around the 1/4 tank mark so that you don't run out of fuel for motor. This is no admission on my part that I may or may not be speaking from experience.
Robert & Cathy McWhirter
1996 Gulfstream Sun Voyager
1995 Exiss Extreme 2 Horse Trailer - Katelyn
2006 Elk River Racing Kart Trailer - Jacob

rvpuller

  • ---
  • Posts: 368
Re: Generac Generator won't Start
« Reply #7 on: December 07, 2012, 05:20:27 PM »
I have the same generator and if it runs with the cleaner I would remove the screw from the bottom of the carb bowl and remove the bowl to see if you have any fuel in it, if not push the primer switch and see it you get any fuel. If no fuel next I would remove the hose at the carb and try the primer again, if you get fuel remove the carb and clean it, I don't think you will need a kit just a good cleaning.I would remove the bowl first because that's where the problem normally is and it's a good time to clean the bowl.

Denny
35 FKTG HH Premier  215/75/17.5 tires. 13" Kodiak Disks
2013 F350 DRW 6.2 V8 4.30 gears
Home Base SC Nebraska

K YoH

  • Posts: 1
Re: Generac Generator won't Start
« Reply #8 on: July 07, 2015, 12:39:53 PM »
Is it possible that you are low on fuel? If the generator runs off of fuel tank, the fuel line to generator is usually around the 1/4 tank mark so that you don't run out of fuel for motor. This is no admission on my part that I may or may not be speaking from experience.

This was my problem. I feel silly for calling an Electrician for a quote.  ($100/hour minimum 4 hours) (Diagnostic)
Yikes!
My Generator just hit 100 hours, I knew it had to be something super simple.

Galoe7

  • Posts: 2
Re: Generac Generator won't Start
« Reply #9 on: September 22, 2017, 09:46:13 PM »
 I have a Generac model number 09712–2. Generter there's 20a and 30a i turned both on did I wrecked my generator I know the 30 you and see if you have the air on and the 20 is regular use now

Rene T

  • ---
  • Posts: 10144
  • Great being on the right side of the grass
Re: Generac Generator won't Start
« Reply #10 on: September 23, 2017, 07:46:17 AM »
I have a Generac model number 09712–2. Generter there's 20a and 30a i turned both on did I wrecked my generator I know the 30 you and see if you have the air on and the 20 is regular use now

Welcome to the forum. I would highly recommend you start your own post to get better exposure. Also, can you rewrite your post? The way it's written it's a little confusing. Give us as much information as possible.
Rene & Lucille & co-pilot Buddy
AKA  Pep N Mem
2011 Chevy Duramax 2500 HD 4X4
2011 Montana High Country 343RL
From the Granite State of NH
& Florida Snowbird in Lakeland FL

rvpuller

  • ---
  • Posts: 368
Re: Generac Generator won't Start
« Reply #11 on: September 23, 2017, 08:28:43 AM »
I have a Generac model number 09712–2. Generter there's 20a and 30a i turned both on did I wrecked my generator I know the 30 you and see if you have the air on and the 20 is regular use now

No you didn't hurt anything, they are separate circuits, you use the 30 and breaker if your rv has a 30 amp service, if you have a 50 amp trailer you would use the 20 anp also but on the second other leg. If you have a 30 amp trailer the 20 amp circuit wouldn't be used.

Denny
35 FKTG HH Premier  215/75/17.5 tires. 13" Kodiak Disks
2013 F350 DRW 6.2 V8 4.30 gears
Home Base SC Nebraska

 

Hosted by Over The Network