EPDM Coatings
rvupgradestore.com Composet Products Custom Yacht Interiors

Author Topic: Solar Install on 2003 Adventurer 38G  (Read 1386 times)

John Hilley

  • ---
  • Posts: 1654
Solar Install on 2003 Adventurer 38G
« on: October 29, 2012, 10:27:56 PM »
Finally finished the solar install. Started with mounting the panels in November 2011 and the controller panel in January 2012. Three Kyocera 135 watt panels, combiner box on roof, 10 gauge cable between panels and combiner, 2 gauge cable through refrigerator vent to basement compartment behind door. Morningstar 45 amp PWM solar charge controller with remote panel, Samlex 2000 watt pure sine wave inverter with remote panel and 30 amp transfer switch. Trimetric 2020 and Tristar remote panel mounted on panel installed at end of kitchen cabinet next to load center where rechargeable vacuum was. Also added the Trik-L-Start to the panel to monitor from inside. Used 2/0 to connect the inverter to battery bank with cable restraints into battery bank box.
2003 Winnebago Adventurer 38G
1999 Jeep Cherokee Sport
1999 Winnebago Brave 35C
  Handicap Lift & Hospital Bed

vlady daddy

  • ---
  • Posts: 104
Re: Solar Install on 2003 Adventurer 38G
« Reply #1 on: October 29, 2012, 10:47:50 PM »
Hello John,

From charge controller, did you went directly to the sine inverter (like a grid inverter) without using banks of batteries ?

Also, I have read professional installers and folks using the 3M VHB double sided tape instead of drilling holes on the roof to secure the solar panel mounts.
Vlad

John Hilley

  • ---
  • Posts: 1654
Re: Solar Install on 2003 Adventurer 38G
« Reply #2 on: October 29, 2012, 11:00:48 PM »
No, I went from the charge controller to the battery with 2 gauge cable and then from the battery to the inverter with 2/0 cable and a 250 amp fuse. I used aluminum angle with T&B TBT20 between the angle and roof for adhesion and water proofing. I also put three screws through each angle.
2003 Winnebago Adventurer 38G
1999 Jeep Cherokee Sport
1999 Winnebago Brave 35C
  Handicap Lift & Hospital Bed

John Canfield

  • Forum Staff
  • ---
  • *
  • Posts: 11936
    • Jane and John's Internet Home
Re: Solar Install on 2003 Adventurer 38G
« Reply #3 on: October 30, 2012, 08:28:14 AM »
Good job John, thanks for the write-up.  I haven't boondocked with our solar since the install this summer, I need to play around with that.

Oh, I saw an amazing 17 amps from our two 145 watt panels a month or so ago - close to the maximum of the panel's rated output  :).
--John
2005 Horizon 40AD, 2006 Jeep Rubicon Unlimited
Our Horizon projects
Our weather

 

Hosted by Over The Network