EPDM Coatings
rvupgradestore.com Composet Products Custom Yacht Interiors

Author Topic: removing side windows and recaulking  (Read 2622 times)

93Coachman

  • ---
  • Posts: 58
removing side windows and recaulking
« on: July 27, 2014, 05:59:25 PM »
What's the best way to remove the side windows in my 93 coachman. We have had a bunch of rain today and I'm seeing leaking.  Previous Owner recaulked them with the old fashioned rope puddy based window type caulk he called rope dope.  I want to redo them with a good silicone caulk  I removed the interior trim ring but dot think this is how. Don't see screws on the outside.   Thanks for and advise. Don in KY

buchanan

  • ---
  • Posts: 734
Re: removing side windows and recaulking
« Reply #1 on: July 27, 2014, 06:12:49 PM »
What's the best way to remove the side windows in my 93 coachman. We have had a bunch of rain today and I'm seeing leaking.  Previous Owner recaulked them with the old fashioned rope puddy based window type caulk he called rope dope.  I want to redo them with a good silicone caulk  I removed the interior trim ring but dot think this is how. Don't see screws on the outside.   Thanks for and advise. Don in KY

 just push them out once the ring is off

SargeW

  • Forum Staff
  • ---
  • *
  • Posts: 6407
  • Life is better on the road!
Re: removing side windows and recaulking
« Reply #2 on: July 27, 2014, 06:18:09 PM »
Start at one of the outside corners with a plastic pry tool or putty knife.  Work the edge into the corner lifting gently as you push. You may need to re-position the tool a few times. Once you get the window to start lifting, continue pulling with your fingers. The type of putty he used will start to release as you pull.  Just be careful on the ladder, when the window starts to come out they can be heavier than they look.
Marty--
2017 Tiffin Allegro Bus 40SP
Cummins ISL 450 HP/Powerglide chassis
Visit our new travel blog! http://www.mytripjournal.com/rvnchickTNG
Support your local Police Officer, Fire Fighter and Military!

93Coachman

  • ---
  • Posts: 58
Re: removing side windows and recaulking
« Reply #3 on: July 27, 2014, 07:08:09 PM »
Great to hear!!    We are wall papering now. So I'll pull them and recaulk them  sounds like killing two birds with one stone.

Molaker

  • ---
  • Posts: 5766
  • We don't camp. We tour.
    • Pumpkin and Us
Re: removing side windows and recaulking
« Reply #4 on: July 27, 2014, 07:35:06 PM »
Get some butyl tape caulk, s/b available at Home Depot, etc.  It is flat and about 1/2"-3/4" wide.  Comes in a roll.  Once you get your window(s) out, clean the surfaces and reinstall with the butyl tape between the window and the wall.
Tom & Joyce and Ditto the "don't tell her she's a dog" Westie
U.S. Navy (Ret)
2014 Winnebago ERA 70X 24' class B Sprinter chassis

Gary RV_Wizard

  • Forum Staff
  • ---
  • *
  • Posts: 61068
  • RVer Emeritus
Re: removing side windows and recaulking
« Reply #5 on: July 28, 2014, 11:38:48 AM »
You don't want silicone except over the top edge when done. Use butyl rubber caulking tape between the outer frame and the sidewall - most any RV or mobile home supply place should have it.

To get the window frame out, remove the inner ring and just push outward (with someone outside to catch it). Work it loose as SargeW described.  Clean up both surfaces, apply new butyl tape, and then re-install. Then use the silicone on the top outer edge and most of the way down the sides. Do not put the silicone across the bottom edge.
Gary
--------------
Gary Brinck
Summers: Black Mountain, NC
Home: Ocala National Forest, FL

93Coachman

  • ---
  • Posts: 58
Re: removing side windows and recaulking
« Reply #6 on: July 28, 2014, 09:38:42 PM »
Tape it is then. Thanks for the tips. 

93Coachman

  • ---
  • Posts: 58
Re: removing side windows and recaulking
« Reply #7 on: July 31, 2014, 05:03:51 PM »
Hey  Gary or Sarge.  Got two of the windows done  that tape is the trick. Looks like it sealed really well.  Should I take a razor blade and trim around the window to remove the excess that seeped out around the window  it would make the job look a lot neater  then hit the top with silicone ??   With your help this bus is gonna be liveable this winter on pine Island   

Molaker

  • ---
  • Posts: 5766
  • We don't camp. We tour.
    • Pumpkin and Us
Re: removing side windows and recaulking
« Reply #8 on: July 31, 2014, 05:09:57 PM »
Hey  Gary or Sarge.  Got two of the windows done  that tape is the trick. Looks like it sealed really well.  Should I take a razor blade and trim around the window to remove the excess that seeped out around the window  it would make the job look a lot neater  then hit the top with silicone ??   With your help this bus is gonna be liveable this winter on pine Island
Don't use a razon blade, it will cut the fininsh of the siding.  Instead, use a plastic putty knife or something similar.
Tom & Joyce and Ditto the "don't tell her she's a dog" Westie
U.S. Navy (Ret)
2014 Winnebago ERA 70X 24' class B Sprinter chassis

SargeW

  • Forum Staff
  • ---
  • *
  • Posts: 6407
  • Life is better on the road!
Re: removing side windows and recaulking
« Reply #9 on: July 31, 2014, 07:40:49 PM »
Yep, Tom nailed it. A good plastic putty knife, or even a plastic razor blade. Trim off the excess putty, then silicone over the top. No more leaks.
Marty--
2017 Tiffin Allegro Bus 40SP
Cummins ISL 450 HP/Powerglide chassis
Visit our new travel blog! http://www.mytripjournal.com/rvnchickTNG
Support your local Police Officer, Fire Fighter and Military!

Rene T

  • ---
  • Posts: 10180
  • Great being on the right side of the grass
Re: removing side windows and recaulking
« Reply #10 on: July 31, 2014, 07:48:42 PM »
After a short time, you'll probably see more of the putty oozing out so you'll need to trim more. Check the tightness of the screws then.
Rene & Lucille & co-pilot Buddy
AKA  Pep N Mem
2011 Chevy Duramax 2500 HD 4X4
2011 Montana High Country 343RL
From the Granite State of NH
& Florida Snowbird in Lakeland FL

93Coachman

  • ---
  • Posts: 58
Re: removing side windows and recaulking
« Reply #11 on: July 31, 2014, 08:31:52 PM »
Thanks. Guys  so far so good. 

 

Hosted by Over The Network